Lowe’s驗廠基本要求
1.驗廠與質量驗廠一起進行審核(清單附后),偏重于質量方面審核.
2.評分:總分為100分,50分就可以及格通過(著重注意,不能出現童工,否則直接不通過,機會都沒有; 出現其它問題還可以重新申請審核),一年一次.
3.要有產品測試報告才可以出貨(ITS或BV產品測試報告,說要一萬多).（建議:一年一次,盡量一次性通過,節省測試成本）
4.沒有主要不良、次要不良之分,AQL水準要求一般取1.5
5.對顏色比較重視,色差要分辨清楚,不可有臟污等.
6.盡量不要用水口料（慎用）生產.
7.對產品外觀、包裝要求較嚴,產品裝箱不能過松或擠壓過緊,包材要起到保護產品的作用,要能通過摔箱測試,裝箱不能短裝.
8.彩標、吊卡之類要有客人簽樣.
9.包裝需設全檢崗位進行全檢.
10.倉庫要有來料待檢區、退貨區等區域標識.
11.需設立專職IQC職位,需有IQC專用來料檢驗記錄表.
12.件制作要有QC責任人員簽名.
13.成品、半成品標示需要改進,要用較正式的標簽,標簽上應有品名、數量、日期等項目,是否合格或不合格（PASS章或紅色標簽）等.
14.在消防方面也是很重視.
During factory certification, the assessor needs to review the following documents from your factory. Please make them ready for review if you have these documents. 在工廠評審過程中，評審員須要查閱下述文件。如 貴公司備有該等文件，請事先由檔案抽出，以便查閱。
（一）廠房平面圖 Factory Layout Diagram
（二）近十二個月準時交貨的統計數據 Last 12 months on time delivery statistical data
（三）近十二個月成品質量抽查的統計數據 Last 12 months final pre-shipment quality audit statistical data
（四）員工招聘 Recruitment
1)招聘守則 Guidelines for Recruitment
2)職位說明書 Job Description
（五）員工培訓 Employee Training
1)員工守則培訓課程大綱 Factory Rules and Regulati***** for Employees
2)個別崗位特殊技能培訓課程大綱 Training contents of skills required for Individual post
3)員工培訓紀錄 Records of Employee Training
（六）質量系統的規範文件 Quality System Policies and Operating Procedures
1）工廠組織架構圖 Factory Organization Chart
2）質量主管的職責介定 Roles and Resp*****ibilities of Key pers***** in Quality Organization
3）質量主管的報告渠道 Reporting channel for pers***** in Quality Department
4）挑選供應商的手續及質量審查程序 Vendor selection procedures and quality assessment procedures
5）對供應商的質量要求及監管 Vendor quality requirements and performance monitoring
6）各質檢崗位的工作指引 Operating procedures for individual Quality control stati*****
7）工藝水平的檢查準則 Workmanship Acceptance/Rejection Criteria
8）來料及退料管理 Incoming material handling and non-conforming material return procedures
9）不良品處理程序 Nonconforming material handling procedures
10）不良品的成因分析及改善措施成效追蹤紀錄 Defect analysis records and countermeasures monitoring
11）質量管理系統的年檢計劃及年檢報告 Master schedule for internal quality system audit, reports of periodical internal quality system audit
12）按質量管理系統的年檢結果擬定的改善計劃及成效追蹤紀錄 Improvement plan against periodical internal quality system audit results and countermeasures monitoring
13）儀器校正計劃 Equipment Calibration Plan
14）儀器校正紀錄 Equipment Calibration Records
15）文件控制（含產品安全規範文件） Document control procedures (including product safety standards)
16）供應商質量表現紀錄 Vendors quality performance records
17）設備保養及維修程序 Machines preventive maintenance and repair procedures
18）條碼掃描儀及條碼檢查程序 Barcode scanners and barcode verification procedures
19) 消防(消防平面圖,應急燈是不否足夠和有效,滅火器是否足夠和有效(丙類-紙張,化學品標準:車間80m2/個,倉庫100m2/個,消防栓有無水,通道是否不少于2m和暢通.)
20)出貨安全(倉庫出入人員是否有管控,空柜是否有檢測和保持記錄,裝柜過程拍照記錄.)
21(宿舍住宿人數是否滿足2m2/人,衛生狀況,廁所是否足夠(男100人以下,每25人一蹲, 100人以上,每增加50人加一蹲,配足夠小便槽.女100人以下,每20人一蹲, 100人以上,每增加35人加一蹲.可飲用的水.工作時間是否符合勞動法,是否有足額購買社會保險,是否有簽勞動合同.)
22)廠醫(廠醫資格證書,每一樓層是否有醫療箱,是否足夠(消毒水,止血貼/粉,藥棉,砂布,幫帶,膠手套,剪刀),員工周年證明)
23)化學品(危險品標識,庫房通風,不能用普通換氣扇,要用防爆型,生產線現場不能保存大量化學品,全部歸入倉庫,只存當天使用的量.)
（七）消防安全政策和操作程序 Fire Safety Precaution Policies and Operating Procedures
我們希望工廠維持一個安全的工作環境并且日常檢查和監督以下方面 We expect the factory maintain a safe working environment with regular review and monitor on:
?在適當?shù)奈恢糜凶銐虻南罍缁鹪O(shè)施、如滅火器、消防龍頭、應急燈、出口指示標志和逃生線路圖等等。這些都要符合中華人民共和國GBJ16-87和GBJ14標準 Sufficient fire fighting equipment are in place, e.g. fire extinguishers, water hydrants, emergency light and exit sign, evacuation diagram, etc. which meets PRC National Standard GBJ16-87 and GBJ140
?保持所有的消防設施運作正常 All fire fighting equipment are under good working conditi*****
?有足夠的應急出口和保持通道暢通無阻 Sufficient emergency exits and unblocked passage
?將易燃化學品（如油漆、稀釋劑等）進行隔離和適當?shù)膬Υ?nbsp;Segregation and proper storage of flammable chemicals, e.g. paints, thinner, etc.