51304518-100
3.PLC控制系統中電磁干擾的主要來源有哪些呢？
(1)來自空間的輻射干擾
空間的輻射電磁場（EMI）主要是由電力網絡、電氣設備的暫態過程、雷電、無線電廣播、電視、雷達、高頻感應加熱設備等產生的，通常稱為輻射干擾，其分布極為復雜。若PLC系統置于所射頻場內，就回收到輻射干擾，其影響主要通過兩條路徑；一是直接對PLC內部的輻射，由電路感應產生干擾；而是對PLC通信內網絡的輻射，由通信線路的感應引入干擾。輻射干擾與現場設備布置及設備所產生的電磁場大小，特別是頻率有關，一般通過設置屏蔽電纜和PLC局部屏蔽及高壓泄放元件進行保護。
(2)來自系統外引線的干擾
主要通過電源和信號線引入，通常稱為傳導干擾。這種干擾在我國工業現場較嚴重。
(3)來自電源的干擾
實踐證明，因電源引入的干擾造成PLC控制系統故障的情況很多，筆者在某工程調試中遇到過，后更換隔離性能更高的PLC電源，問題才得到解決。
PLC系統的正常供電電源均由電網供電。由于電網覆蓋范圍廣，將受到所有空間電磁干擾而在線路上感應電壓和電路。尤其是電網內部的變化，入開關操作浪涌、大型電力設備起停、交直流轉動裝置引起的諧波、電網短路暫態沖擊等，都通過輸電線路到電源邊。PLC電源通常采用隔離電源，但其機構及制造工藝因素使其隔離性并不理想。實際上，由于分布參數特別是分布電容的存在，隔離是不可能的。
(4)來自信號線引入的干擾
與PLC控制系統連接的各類信號傳輸線，除了傳輸有效的各類信號之外，總會有外部干擾信號侵入。此干擾主要有兩種途徑：一是通過變送器或共用信號儀表的供電電源串入的電網干擾，這往往被忽略；二是信號線受空間電磁輻射感應的干擾，即信號線上的外部感應干擾，這是很嚴重的。由信號引入干擾會引起I/O信號工作異常和測量精度大大降低，嚴重時將引起元器件損傷。對于隔離性能差的系統，還將導致信號間互相干擾，引起共地系統總線回流，造成邏輯數據變化、誤動和死機。PLC控制系統因信號引入干擾造成I/O模件損壞數相當嚴重，由此引起系統故障的情況也很多。
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
NEW Allen Bradley 1403-DMA Powermonitor II Display Module Series B FRN 1 10
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
ITW Ransburg 74944-100 Rev E Module A10220-01 Rev L
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
ITW Ransburg 74944-100 Rev E Module A10220-01
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
GE 6VAF343003B-A2 Variable Frequency Drive 3 HP 460V AF-300
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Sti MS46-30-1215-R-FP-CX1 Light Curtain Receiver 48" 70158-1512
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
ITW Ransburg 74944-56 Rev G Module 74943 Rev A
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
ITW Ransburg 74944-111 Rev R Module A10220-01 Rev H
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Sti MS46-30-1215-R-FN-CX1 Light Curtain Receiver 48" 70112-1034
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Sti MS46-30-1045-R-FP-CX1 Light Curtain Receiver 41" 70158-1531
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
NEW NTN 6218LLUC3/EM Single Row Deep Groove Ball Bearing 6218LLUC3/L627
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Cleaver Brooks ControlBus Module 833-2757 CB Hawk
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Allen Bradley 1791-0A32/B Block I/O Module B01
Pre-Owned
2 258 72
Free Shipping
Only 1 left!
9 Sold
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Digital Monitoring Products PC-0074 R8 Control Board Rev J
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Digital Monitoring Products PC-0074 R8 Control Board Rev K
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
NEW Ametek Drexelbrook TFL30 Relay Output Vibrating Level Switch
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Matrox MG-1281 Graphics Controller Card MG-1024/8/B Rev 02
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Allen Bradley 1791-0A32 Block I/O Module Ser B Rev B01
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Westinghouse M300 149D946G02 Over Excitation Protection-3 Sub 5
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Honeywell 51305072-200 I/O Card CLCNIO Rev F
Pre-Owned
2 258 72
Free Shipping
Only 1 left!
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Allen Bradley 1791-0A32 Block I/O Module Ser B Rev D01
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
NEW Ametek Drexelbrook TFL30 Relay Output Vibrating Level Switch TF Series
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Allen Bradley 1791-0A32 Block I/O Module Ser B Rev C01
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Giddings & Lewis 31-50231N14 CPU Board FS054593-0002
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Honeywell TC-ODD321 Experion DC Output Module 97067175-A01 Rev G01
Pre-Owned
2 258 72
Free Shipping
2 Watching
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Fujitsu DCA6-MEM1 Flashwave 4300 Processor Card FC9520MEM1
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Westinghouse 4D33865G01 PCD I/O Auxiliary Power Supply Module Sub 07
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Yokogawa RS42-ON RS422 Interface Module RS42-ON without cover
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Electro-Craft 0670-07-021 Permanent Magnet Motor Tach
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Schroff 60800-424 14 Slot VME I/O Bus Backplane Board
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Westinghouse 7381A01G04 Ovation Batch Processor Board 8MSP8 Sub AC
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
RiL Model CL6000 Supercal Multimeter
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Superintend VRE-80MUS Residual Current Monitor Unit
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
NEW Hubbell KS-17P8-G-P2-F1-QS Kemlux Industrial Lamp Ballast Tank no cover
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Allen Bradley 592-EC2BC Solid State Overload Relay Ser B FRN 3 003 3-15A
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Ametek AC2000 Battery Charger Interface Assembly 196162-001 / 192819A-001
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Ametek AC2000 Battery Charger Interface Assembly 192780-001 / 192819-001
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Bently Nevada Dual Velocity Monitor 3300/55-01-04-02-02-03-00-06-00
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Bently Nevada Dual Velocity Monitor 3300/25-XX-XX-XX-03-01-02-00
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Hach 19180=A=0211 Series 9100 Amperometric Meter 9180/Amp
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
NEW Ariel A-15436-A Compressor Discharge Seat DIS VLV SEAT ASSY 140CEX PRC
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Yaskawa CMPC-CM34C-3 Motionpack 34 Servo Controller
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
ABB DSQC 210 Safety Board YB560103-AM
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Westinghouse 4D33900G19 Ovation Auxiliary Power Supply Module Sub 14
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Allen Bradley 1791-0A32 Block I/O Module Ser B
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
NEW Vega SWING61 CUANVXNZX Vibration Level Switch
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Allen Bradley 1756-L1/A ControlLogix Processor w/ 1756-M1/A Rev D01
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
NEW Vega SWING61 CUANVXNZX Vibration Level Switch 6162825/001
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Schweitzer SEL-311A Protection and Automation Module 0311A00H14254X1
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Premisys 608800-393-600 CPU-3 BCON SS Card Rev D2
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
NEW Fisher RGXBELLX082 Bellows Kit GX DN50 HASTC/316
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
TRW Nelson LP MP-1 Stud Welder Slot Rack Chassis 66-03-67a
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Moore Industries AOM/IO/TI4/IP[DIN] Temperature Input Module
Pre-Owned
2 258 72
Free Shipping
Watch
Get fast shipping and excellent service when you buy from Top-rated sellers
Item image
Allen Bradley 705-C0D103 Motor Starter Series K Size 2 25 HP 600 VAC
Pre-Owned
2 258 72
