TDM4.3-020-300-W0傳感器的結構及工作原理 水中爆炸壓力傳感器的結構如圖1所示。 該傳感器以具有壓電效應的電氣石為敏感元件，內部填充硅油，采用高絕緣密封膠進行密封。工作時，將傳感器放入水下離爆炸源一定的距離，當炸藥爆炸后產生的壓力通過水，以沖擊波的形式向各個方向傳播，電氣石晶體將感受到的壓力信號轉換成的電信號，從而實現能量的轉換。 2 傳感器的性能檢測 2.1 傳感器的靜態標定 （1）標定設備：TDM4.3-020-300-W0傳感器的校準設備為JS-2500（250MPa）活塞壓力計；準確度等級為0.02。 （2）標定方法：采用加載法，每個傳感器預壓3遍后開始校準，校準3次取平均值，按最小二乘直線法計算得出傳感器的靜態靈敏度、非線性靜態標定結果見表1。 由表1標定的結果得出：MCRI傳感器的非性為1.36％．靈敏度為26.12pC/MPa。 2.2 動態標定 （1）標定設備：美國PCB公司913B02型水動力脈沖標定裝置（含內裝電荷放大器的136A型標準傳感器）。 （2）標定方法：采用比較校準落球標定法，將傳感器按照靜態靈敏度配置模塊式電荷放大器，然后，與標準傳感器同時安裝在標定接頭上，將鋼球從不同的高度自由下落，撞擊高壓液壓裝置中的活塞，產生的半正弦波壓力（也是一種脈沖壓力）經過液壓油傳遞給傳感器，以參考傳感器為基準。將被校傳感器的曲線與標準傳感器的曲線進行幅值和波形一致性的校準，求得傳感器的動態校準非線和靈敏度。傳感器的動態標定結果見表2。 由表2的結果可以得出：傳感器的非線性為0.17％；平均靈敏度為1TDM4.3-020-300-W023.76mV/MPa。 由靜態和動態標定得到的傳感器的非線性值不一樣，這是因?yàn)楫?dāng)傳感器的絕緣電阻不是很高時，在靜態標定中，由于加載時間較長，傳感器會產生一定的零漂，從而影響傳感器的線性指標；另外，動態標定使用的設備，由于密封的問題，標定只能到達29MPa的壓力，遠低于量程上限，所以，動態標定的非線性比靜態標定的非線性指標高。 3 水池試驗 （1）試驗條件：水池直徑為85m，深度為15m；爆炸源為RS211，重量為1.01kg；傳感器安裝深度為5m，離爆炸源水平距離為3m。 （2）試驗方法：試驗時，將研制的傳感器及測試系統與美國PCB公司的138型激波傳感器和專用的信號采集裝置同時進行測量對比。試驗波形曲線如圖2所示。傳感器的爆炸沖擊波能及氣泡能測試測試數據見表3。 TDM4.3-020-300-W0從傳感器的沖擊波能及氣泡能測試波形曲線，得到MCRI 5#，MCRI 6#的沖擊波形上升前陡峭，抗干擾能力強，與美國PCB公司生產的PCB138-1傳感器測量結果的比較，獲得的沖擊波波形基本一致?？傊?，由測試結果可以證時：獲得的沖擊波波形基本一致?？傊?，由測試結果可以證明：整個測試系統的動態測試具有抗干擾能力強、強度高、測量壓力范圍寬。
----商務熱線---廈門興銳達自動化設備有限公司
聯系人：王文光
++QQ:2851759104
手機：15359273780
電話：0592-5580707 400-855-5103轉001
傳真：0592-5361289
郵箱：2851759103@qq.com
網址：http://www.xmxrdauto.com
TDM4.3-020-300-W0
TDM4.3-030-300-W1
TDM1.2-050-300-W1-000/S107
TDM1.3-030-300-W1-000/S102
TDM1.3-100-300-W1-000/S102
TDM1.3-100-300-W1-000/S100
TDM1.3-030-300-W1-000/S105
TDM1.3-050-300-W1-000/S105
TDM1.3-100-300-W1-000/S105
TDM7.1-030-300-W1/S102
TDM1.4-050-300-W1-000
TDM1.4-100-300-W1-000
TDM1.2-050-300-W1-000/S100
TDM1.2-030-300-W1-000/S107
TDM1.2-050-300-W1-000/S108
TFM3.1-050-300-W1-220
TFM3.1-050-300-W1-220
TFM3.1-050-300-W1-1
YASKAWA CP03B PC CONTROLLER BOARD DF8100713
Yaskawa SGMD-40AWA-YRI2 4000W
YASKAWA SGMG-20A2V-HS21 AC SERVO MOTOR
Yaskawa Drive Servopack CPCR-MR-374 K CPCRMR374K
Yaskawa Servopack CPCR-MR 052GC CPCRMR052GC
Yaskawa USASEM-02YRS12 154w 0.49
YASKAWA SERVO DRIVER SGDH-60DE-OY 400V
YASKAWA SERVO DRIVER SGDH-60DE-OY 400V
YASKAWA SGDS-04A01A & SGMAS-04ACA21
YASKAWA SERVOPACK SGDA-01AS
YASKAWA ELECTRIC JVOP-130U
YASKAWA AC Drive CIMR-V7CU27P54
YASKAWA USAMED-09BA2K SERVO MOTOR ENCODER UTOPH-600VB
Yaskawa 100W Servo Drive SGDS-01A32A
Yaskawa JANCU-MRY01B-1 REV.E02 EDF9200676-D0
Yasnac RX Yaskawa STARTER? DF8100616
YASKAWA MP2200 JAPMC-CM2320 MODULE
YASKAWA SERVO MOTOR SGMPS SERVOPACK SGDS-01A12A DRIVE
YASKAWA SGMGH-44A2A61 AC SERVO MOTOR SGMGH44A2A61
MC4VA 2ND YASKAWA EEVA-5IKM EEVA5IKM
Yaskawa SGMAH-04AAA21 400W 200V
YASKAWA SERVOPACK SGDV-R90A01A 100W
Yaskawa CIMR-E7U22P2 CIMRE7U22P2 Varispeed Drive
Yaskawa AC Servo Motor SGMS-20A6AB #6307LR
Yaskawa AC Drive GPD 305/J7, Model# CIMR-J7AM40P2!
YASKAWA DCS JAMSC-B1058 JAMSC-B1070
Yaskawa CIMR-G5A21P5 CIMRG5A21P5
YASKAWA SGMG-44A2BAC
Yaskawa servopack Servo Drive SGDA-04ASP 400W
Yaskawa SGDS-01A12A 3 Phase 230VAC .91A 100W
YASKAWA SERVO MOTOR SGM-02U3B4L
Yaskawa MTRY543 Inverter 5 HP 5400 RPM 230/460
Yaskawa CDBR-2022B Braking Unit Brake CDBR2022B
YASKAWA ELECTRIC DR1-A3BC USPP DR1A3BC
YASKAWA ELECTRIC DR1-01BC USPP DR101BC
YASNAC YASKAWA JANCD-HSP01
YASKAWA JVOP-100 USED DIGITAL OPERATOR KEYPAD JVOP100
YASKAWA SERVOPACK SGD-02BP SGD-02BPY38
YASKAWA AC Drive CIMR-V7AM20P71
YASKAWA SGMPH-02A1A41 AC Servo Motor 200W
YASKAWA MAGNETEK CIRCUIT BAORD JANCD-PC20
Yaskawa Servo Motor SGMGH-44DCA6H
YASKAWA VARISPEED CIMR-V7CU40P7 CIMRV7CU40P7
YASKAWA CIMR-P5U4011
Yaskawa VFD C1MR-V7AM43P7 5hp 460 VAC NIB
YASKAWA JANCD-HA03 PCB BOARD
Yaskawa SGDH-50DE 3363C _JUSP-NS300
YASKAWA CIMR-22CS
Yaskawa Electric Servopack Servo Drive Model SGDB-15ADG
Yaskawa 100W Servo Drive SGD-01AP
YASKAWA CACR-SR15SZ1SDY214
YASKAWA 230 V 3 PHASE VS MINI DRIVE CIMR-XCBA21P542
YASKAWA ELECTRIC JANCD-MM13B REV. B
Yaskawa JUSP-NS100
0190-06319 YASKAWA
JANCD-FC242 Yaskawa
Yaskawa Thermal Overload Relay, RHP-15/7.5, USED, WARRANTY
YASKAWA TDB-P75LB2/TDB-P75LB
Yaskawa 100W Servo Drive SGDP-01AP
YASKAWA SGMP-02A3G22,HD CP-20A-11-J202B-SP
YASKAWA DRIVEPACK SERVO UNIT SGDC-50DSA
Yaskawa Motor USASEM-15AC10B USASEM15AC10B
Yaskawa JGSM-06 Position Controller
YASKAWA ELECTRIC DP9420007 NSPP DP9420007
YASKAWA YPCT31094-1
YASKAWA ELECTRIC SERVOPACK MODEL SGDA-08AS 200-230VAC
SGM-04U3B4L Yaskawa AC Servo Motor SIGMA I 200VAC 2.6A
Yaskawa JANCD-SP01, DF8100269, sed, WARRANTY
Yaskawa SGDS-08A15A
YASKAWA CIMR-V7AM43P7
YASKAWA CIMR-P7U4015
YASKAWA CIMR-J7AM40P2 J7 DRIVE CIMRJ7AM40P2
JANCD-FC224 Yaskawa
YASKAWA SGM-08A2FJ34 FUJI SAM1300
YASKAWA AC Drive CIMR-V7CU21P54
USASEM-10HS13 Yaskawa
YASKAWA CIMA-J7AA20P4 0.4kW CIMRJ7AA20P4
YASKAWA 100W AC Servo Drive SGDS-01A01A
Yaskawa RKH-35/8B Thermal Relay, 8A, USED, WARRANTY
Yaskawa CIMR-37A
Yaskawa Electric SGDF-A1CS
YASKAWA R01SA
YASKAWA SGDA-08AP SERVOPACK 230V 750W 4.4A 1PH
Yaskawa GPD506/P5 CIMR-P5M4037
Yaskawa JANCD-MM20 REV B PC Board
Yaskawa Memocon-SC JAMSC-IF64 b module card
YASKAWA SGDV-5R5A11A SERVO PACK WORKING
YASKAWA SG-DB-15ADG SERVO PACK
YASKAWA Inverter CIMR-J7AA21P5
Yaskawa 120CPS11300
Yaskawa CDMR-MR-5.5K
YASKAWA CIMR-F7U42P21F
Yaskawa CIMR-E7U4011
Yaskawa SERVOPACK CACR-UIR020202FD CACR-UIR 020202FD P00 D00
Yaskawa SGM-A5L3B2L
Yaskawa USAGED-09A22K
YASKAWA UGTMEM-06LSF21
YASKAWA SII AMPLF.MATING CONN,MAIN AC PWR30W TO 400W
YASKAWA USASGM-15-HGA1 SERVO MOTOR USASGM15HGA1
Yaskawa 87350-23001 PLC Module 8735023001
Yaskawa SGDS-01A01A & SGMPS-01ACA21
YASKAWA B2914 Bestact
Yaskawa Electric Servopack SGDM-02ADA SGMAH-02AAA41
Yaskawa JAMSC-B1074-1 B1074-1V
Yaskawa 87350-12111-S206 PLC Module 8735012111
Yaskawa 87350-24004-S011 PLC Module 8735024004
Yaskawa CIMR-XCAA20P2 0.2kW CIMR-XCA A20P2
Yaskawa Drive Servopack CPCR-MR-162 CPCRMR162 MR162
YASKAWA SGDH-20AE
YASKAWA SG0B-1AADG
YASKAWA CACR-SR05B21SSY367
YASKAWA UUX000441
Yaskawa INDEXER UNIT JUSP-NS600
SGMP-15AWYR12 YASKAWA
YASKAWA JANCD-MM20 REV.B DF8202136
Yaskawa CACR-SR-10SB1AF
Yaskawa Encoder MOTOMAN # 479508-2
YASKAWA CACR-SR15BC1KSY392
YASKAWA DF8100494
YASKAWA ELECTRIC SERVOPACK JUSP-ACP07AA
YASKAWA UGCMEM-08MC45 UGCMEM-08-MC45
YASKAWA SGM-02U3B4CL 0.637NM SERVO MOTOR
YASKAWA SERVO DRIVE SGDM-A5ADA 50W
YASKAWA MAGNETEK PC CIRCUIT BAORD JANCD-MB20
YASKAWA CIMR-G5C4011 VARISPEED DRIVE 616G5 CIMRG5C4011
Yaskawa JANCD-GFG01 PCB Board
YASKAWA SERVOPACK SGDS-08A12A
Yaskawa JANCV-MBB01 CNC PCB Board
Yaskawa JANCD-HA02 PC Board
Yaskawa VFD 1hp 460v CIMR-V7AU40P4
YASKAWA SGDS-08A12A
Yaskawa Electric Servopack SGD-01AN Servo Drive NIB SGD01AN
Yaskawa JANCD-MIO04
YASKAWA JEPMC-AN2910
YASKAWA JANCD-MI004 DF92012214
YASKAWA SGM-02U3B2L
YASKAWA JASPD-DS005B CPCC-PP160A POSITIONPACK-160A
Yaskawa SGDV-2R8A01A 002000 Servopack FreeShip
YASKAWA ELECTRIC 73600-A0151PC COMPONENTS
Yaskawa AC servomotor USAREM-02YR21
YASKAWA SERVO DRIVE SGD-01BP CNC/ROUTER
YASKAWA Servopack CACR-PR15
Yaskawa UGMMEM-13AA1S RPM 3000 (2731)
Yaskawa Thermal Overload Relay, RH-18/0.8MP, USED, WARRANTY
Yaskawa Thermal Overload Relay, RH-18/0.1MP, USED, WARRANTY
Yaskawa Thermal Overload Relay, RH-18/0.37P, USED, WARRANTY
Yaskawa CIMR-G7U4018 AC Drive 480V - NIB! CIMRG7U4018
YASKAWA CIMR-JU4A0001BAA DRIVE CIMRJU4A0001BAA
Yaskawa Board JANCD-FC200-1 JANCDFC2001
YASKAWA ABSO CARD JANCD-MFC03-2
Yaskawa 15W AC Servo Drive SGD-A2CPY14 SGD-A2CP
YASKAWA SERVOPACK SGDS-08A75A 750W
YASKAWA YPCT11071-1A YPCT110711A ETC610021-S5016
Yaskawa JANCD-I002, WARRANTY
YASKAWA USASEM-50FJ12 AC SERVO MOTOR 3000RPM
YASKAWA ELECTRIC JRMSI-MB21 USPP JRMSIMB21
Yaskawa Minertia J02SC2 909971-2
Yaskawa 87820-03200 PLC Module 8782003200
Yaskawa Servopack CPCR-02-TF1A
YASKAWA ELECTRIC JANCD-CP07C USPP JANCDCP07C
YASKAWA SERVOPACK SGDS-15A12A
Yaskawa SGMDH-32A2A-YR13
Yaskawa servo motor USAGED-09A22K
YASKAWA JARCR-XFL02B
YASKAWA USAREM-03CFJ51 AC SERVO MOTOR 3000RPM
Yaskawa 100W Servo Drive SGDS-01A12A
Yaskawa AC Servo motor USASEM-05A32 462W
yaskawa servomotor sgms-506ab
Yaskawa 200W AC Servo Motor SGME-02AF12B
YASKAWA POWER CARD PX-3081392 PX40-T032S04
Yaskawa USAFED-02FS2S USAFED02FS2S
Yaskawa Yasnac CPS-15
Yaskawa UGCMEM-04-MC55 UGCMEM04MC55
Yaskawa Servopack SGDF-A2CS Free Ship
YASKAWA CONTACTOR HC-4E HC-4E2T THERMAL RELAY RH-18
Yaskawa 87350-11000 PLC Module 8735011000
Yaskawa CIMR-F7U21P5
YASKAWA SGM-02A312
MAGNETEK YASKAWA CIMR-G5M47P51F IMPULSE G+ SER. 2 ADJUSTABLE FREQUENCY/ VECTOR
CRANE CONTROLS GPD515C-B021 G5M47P5
YASKAWA ETC613041 DRIVE BOARD PCB 9AMP 5HP 460V
Yaskawa JGSM-06 Position Cont Unit 73051-00060 JGSM06
JANCD-FC310 Yaskawa
Yaskawa Servo Motor SGMGH-44DCA6F
Yaskawa SGM-A3A314
YASKAWA JANCD-XIF03-1
Yaskawa 120 DDO 343 10 120DDO34310
Yaskawa Electric SGDA-04AS AMAT 0870-01011
Yaskawa DCP JUSP-DCP
Yaskawa JPDC-C024 ETC003421
YASKAWA UAASKA-11HNK11
Yaskawa Servopack SGDH-01AE, SGDH-01AE YA11 1080-00080
Yaskawa Yasnac CNC B-series PCB JANCD-ESR01-23
Yaskawa SGM-02A312
Yaskawa CIMR-VU4A0018FAA
Yaskawa Servo Motor (62-0017)-SGMG-13A2ABC
Yaskawa SGMAH-08AAA61 750W
YASKAWA SGDL-04AS SERVOPACK 200V
YASKAWA DRIVE INVERTER HEAT SINK CSET21043
Yaskawa Electric USAREM-07CENX
Yaskawa AC Spindle Motor # UAASKA-08LYA11 7.5kw
Yaskawa, Servopack Servo Drive SGDA-04AS
Yaskawa CIMR-G5M47PS
Yaskawa V1000 Variable Frequency Drive CIMR-VU2A0020FAA
Yaskawa JASP-MPI03B PCB Board
Yaskawa ETP170170 PCB Power Board
Yaskawa AZRU-003 CNC Board
Yaskawa CIMR-VU4A0031FAA
yaskawa gearmotor sh10va-s50a6
YASKAWA AC SERVO MOTOR SGM-02B312 200WATT 2.7amp
Yaskawa NPSA-HC90-T25 Thyristor Exciter Module
Yaskawa ETC008784-S0200
YASKAWA 217IF CP-317/217IF JACP-317217
Yaskawa USADED-22-YR22 2260W 10.8N.m 14A 2000RPM
CACR-PR03AC3ER Yaskawa CACRPR03AC3ER
Yaskawa Feedback Unit TFUE-05ZC7
Yaskawa 120 DDI 343 00 120DDI34300 JAMSC-120DDI34300
